ACG Sevcon Display

[ Pobierz całość w formacie PDF ]
//-->SEVCON Display ManualCopyright © 2009-2013 American Custom Golf Cars, Inc.Page1SEVCON LCD DisplayTheSEVCONLCD display has following functions:Battery State of Charge (SoC)shown on bar graph at right of the screen and as percent % at top of the bar graph(shown above as 78%)see IMPORTANT INFORMATION on next page.TripDistance Traveled in miles in NN.N format (shown above as 1.7 mi.)OdometerTOTAL Distance Traveled in miles in NNNN.N format(shown above as 1.7 mi.)Vehicle Speedin MPH and KPH shown on semi elliptical bar graph(shown as 0 MPH/KPH above)Direction– Monitors the position of the “Direction Control Switch” and shows:Dfor Forward Drive (as shown above)Nfor NeutralRfor Reverseindicates to CHECK the Electrolyte Level in Flooded Traction Batteriesto reset the indicator hold the upper arrow button for 2 seconds[#].Copyright © 2009-2013 American Custom Golf Cars, Inc.Page2Display Panel - Battery State of Charge (SoC)IMPORTANT INFORMATIONBattery Percent Charge Information on SEVCON DisplayThe Battery charge level indicates the relative state of charge of the Traction Battery andNOT the remaining driving range of the vehicle.Its algorithm is based on the PEAK Traction Battery Pack Voltage, which in turncalculates the APPROXIMATE charge of the Traction Battery.The indicator may not always show 100% when the vehicle is first turned on even if theOn-BoardDelta-Qcharger indicates 100% or full charge condition.(Green LED ON – seeCharging ProcedureinOwner Manualfor more detail).This condition is not a defect as the computerized “smart”Delta-QOn-Board Chargermay under certain conditions stop the charging before achieving the maximum potentialvoltage.The ambient and battery temperatures are monitored by the charger and the charge cycleis automatically terminated based on internal charge algorithm that is matched to thespecific type of Battery, which is used in your vehicle.The charge algorithm is designed to maximize the battery life and to prevent batterydamage by overcharge.Initially when the vehicle is FIRST driven after delivery or whenever Traction Battery isserviced, the vehicle MUST be driven so that a discharge level of 69% or less isachieved, and the Traction Battery MUST BE FULLY CHARGED thereafter, in orderfor the State of Charge bar graph indicator in theSEVCONDisplay to self reset to100% indication.If the Traction Battery is not deeply discharged (to below 69%) the State of Charge willgenerally not indicate more than 80% even if the On-BoardDelta-QCharger indicatesFULLY Charged condition.For long battery service life, the vehicle should not be operated when the indicatedCharge Level is 20% or less, and need not to be re-charged if the Display Indication is80% or more.Copyright © 2009-2013 American Custom Golf Cars, Inc.Page3Display Screen – Other FunctionsMain ScreenMain screen will display Direction, Speed and Battery Charge Level, it also displays Trip and Odometer(total miles) mileage traveled.If the low water battery symbol appears please check the water level in all batteries.To clear the low water battery symbol push upper arrow button[#]2 times; this will clear the lowwater level symbol.NOTE:The vehicle MUST be in neutral (N) when you first turn the key “ON”; thereafter you can selectforward (F) or reverse (R). The car will not move unless you start in neutral (N).To proceed to a 2ndScreen push center arrow button[8 ]once.Copyright © 2009-2013 American Custom Golf Cars, Inc.Page42ndScreenVEHICLE STATUS MONITORSection ABatteryTrac Drive StatusSection B1.Cont. Temp. (ControllerTemperature)2.3.4.5.Motor VoltsMotor AmpsMotor RPM (Rotations Per Minute)Motor Torque in Percent (%)shows Battery Nominal Voltageshows current statusThese values will change as soon as you start driving the vehicle. This will also let you monitor and diagnose thecondition of the motor and controller .To proceed to a 3rdScreen push center arrow button[8 ]once.Copyright © 2009-2013 American Custom Golf Cars, Inc.Page5 [ Pobierz całość w formacie PDF ]